Wisconsin Administrative Code
Department of Natural Resources
NR 400-499 - Environmental Protection - Air Pollution Control
Chapter NR 422 - Control Of Organic Compound EmissionsFrom Surface Coating, Printing And Asphalt Surfacing Operations
Section NR 422.132 - Wood door coating
Universal Citation: WI Admin Code ยง NR 422.132
Current through August 26, 2024
(1) APPLICABILITY.
(am) Except as provided in par. (bm), this
section applies to the wood entry or passage door coating lines of any wood
entry or passage door coating facility that is either of the following:
1. Located in the county of Kenosha,
Milwaukee, Ozaukee, Racine, Washington, or Waukesha and which has maximum
theoretical emissions of VOC from all wood entry or passage door coating at the
facility greater than or equal to 25 tons per year.
2. Located in the county of Kewaunee,
Manitowoc, or Sheboygan and which has maximum theoretical emissions of VOC from
all wood entry or passage door coating at the facility greater than or equal to
100 tons per year.
(bm)
This section does not apply to either of the following:
1. Flat wood panel coating lines subject to
s.
NR 422.13.
2.
Adhesives and adhesive primers subject to s.
NR 422.127.
(2) EMISSION LIMITATIONS AND APPLICATION REQUIREMENTS.
(a) No owner or operator of an
automated wood entry or passage door coating line may cause, allow or permit
the emission of any VOCs in excess of:
1. 0.77
kilograms per liter (6.9 pounds per gallon) of coating, excluding water,
delivered to an applicator that applies any coating on or after May 31, 1995,
but before May 1, 1997.
2. 0.64
kilograms per liter (5.7 pounds per gallon) of coating, excluding water,
delivered to an applicator that applies any coating on or after May 1,
1997.
(b) An owner or
operator of a wood entry or passage door coating facility shall only apply
coatings using electrostatic application, flow coating, dip coating, a
low-pressure spray method, paint brush, hand roller or roll coater. All
applications equipment shall be in proper operating condition and used in
accordance with proper operating procedures.
(3) RECORDKEEPING REQUIREMENTS. Any facility subject to this section shall comply with the requirements applicable under s. NR 439.04(5).
Disclaimer: These regulations may not be the most recent version. Wisconsin may have more current or accurate information. We make no warranties or guarantees about the accuracy, completeness, or adequacy of the information contained on this site or the information linked to on the state site. Please check official sources.
This site is protected by reCAPTCHA and the Google
Privacy Policy and
Terms of Service apply.
