New Jersey Administrative Code
Title 7 - ENVIRONMENTAL PROTECTION
Chapter 27B - SAMPLING AND ANALYTICAL PROCEDURES
Subchapter 4 - AIR TEST METHOD 4: TESTING PROCEDURES FOR DIESEL-POWERED MOTOR VEHICLES
Section 7:27B-4.7 - Procedures for the visible smoke, indicator light check, and visual fuel leak tests

Universal Citation: NJ Admin Code 7:27B-4.7

Current through Register Vol. 56, No. 24, December 18, 2024

(a) An inspector conducting a visible smoke test to determine a diesel vehicle's compliance with the inspection requirements at N.J.A.C. 7:27-14.5(d)1 and (e)1 shall perform the test as follows:

1. Place the vehicle in neutral gear with all accessories off and the emergency or parking brake secured;

2. Increase the engine speed to an engine speed greater than the idle mode, and observe the exhaust emissions and crankcase emissions for visible continuous smoke;

3. If there is visible smoke in the exhaust emissions or crankcase emissions for a period in excess of three consecutive seconds, the motor vehicle has failed the smoke test; and

4. If there is no visible smoke in the exhaust emissions or crankcase emissions for a period in excess of three consecutive seconds, the motor vehicle has passed the smoke test.

(b) An inspector conducting an indicator light check test to determine a diesel vehicle's compliance with the inspection requirements at N.J.A.C. 7:27-14.5(d)2 shall perform the test as follows:

1. Determine if the check engine light is functional as follows:
i. Turn off the motor vehicle's engine;

ii. Turn the motor vehicle ignition system to the KOEO position;

iii. If the check engine light is not functional, the motor vehicle has failed the indicator light check test; and

iv. If the check engine light is functional and remains illuminated with the engine on, the motor vehicle has failed the inspection;

2. If the vehicle is equipped with a DPF, determine if the DPF is functional as follows:
i. If the motor vehicle is in regeneration mode, then the vehicle cannot be inspected;

ii. Turn off the motor vehicle's engine;

iii. Turn the motor vehicle ignition system to the KOEO position; and

iv. If the DPF light is not functional, the motor vehicle has failed the indicator light check test;

3. If the vehicle is equipped with a SCR, determine if the SCR is functional as follows:
i. Turn off the motor vehicle's engine;

ii. Turn the motor vehicle ignition system to the KOEO position;

iii. If the SCR light is not functional, the motor vehicle has failed the indicator light check test;

iv. If the DEF tank gauge indicates empty or no fluid, the motor vehicle has failed the inspection.

(c) An inspector conducting a visual fuel leak test to determine a motor vehicle's compliance with the visual fuel leak test requirements at N.J.A.C. 7:27-14.5(d)3 and (e)3 shall examine the fuel system for the presence of any leaking fuel. If any fuel is visibly leaking from the motor vehicle, the motor vehicle has failed the visual fuel leak test.

Disclaimer: These regulations may not be the most recent version. New Jersey may have more current or accurate information. We make no warranties or guarantees about the accuracy, completeness, or adequacy of the information contained on this site or the information linked to on the state site. Please check official sources.
This site is protected by reCAPTCHA and the Google Privacy Policy and Terms of Service apply.