Sec. 5.
(a) Sources
subject to the requirements of this rule and the requirements of 326 IAC 20-26
shall comply with the requirements of 40 CFR 63.784 * and 40 CFR 63.785 *, as
incorporated by reference in 326 IAC 20-26, in lieu of this section.
(b) Compliance requirements applicable to
surface coating operations at a source subject to this rule are as follows:
(1) Compliance with the VOC emissions
limiting requirements of section 4(a) of this rule shall be achieved on as
applied basis for each operating day for the following products:
(A) Coatings.
(B) Cleaning materials.
(2) Compliance with the work practice
standards of section 4(b) of this rule shall be achieved each operating day.
(3) Compliance with the VOC
emissions limiting requirements of section 4(a) of this rule shall be
demonstrated using 40 CFR 60, Appendix A, Method 24*. However, in lieu of
testing each container of coating for VOC content, the alternative procedures
that follow may be used:
(A) If a coating as
supplied by the manufacturer is applied to the substrate, in lieu of testing
each container of coating using 40 CFR 60, Appendix A, Method 24*, a source
subject to this rule may use the following alternative compliance procedure:
(i) Use a certificate issued by the
manufacturer certifying the VOC content for each batch of coating.
(ii) Notify the coating applicators that they
shall not add any thinner to the coatings.
(iii) Specify the procedure to be used to
notify the coating applicators in the compliance plan required to be submitted
in section 7(b)(1) of this rule.
(B) From May 1 through September 30, thinner
may not be added to any general use coating. If a thinner is added to a coating
before its application to the substrate, in lieu of testing the coating as
applied using 40 CFR 60, Appendix A, Method 24*, a source subject to this rule
may use the following alternative compliance procedure:
(i) Use a certification from the coating
manufacturer for each batch of that coating certifying its VOC content as
supplied.
(ii) Record the volume of
coating used.
(iii) Record the
volume of thinner used.
(iv) Record
the VOC content of thinner used.
(v) Type of coating.
(4) In the compliance plan
required to be submitted to the department by section 7(b)(1) of this rule, the
source shall specify the compliance procedure or procedures allowed under
subdivision (3) that it intends to use to demonstrate compliance with the VOC
emissions limiting requirements of section 4(a) of this rule. If the source
desires to use a compliance procedure other than one (1) of the three (3)
described in subdivision (3), the source shall include in its compliance plan
an application for approval by the department and the U.S. EPA of the proposed
compliance procedure, subject to the following conditions:
(A) The application shall include a
demonstration that there is a definite and consistent relationship between 40
CFR 60, Appendix A, Method 24* results and the alternative procedure
results.
(B) The source shall
ensure that the coatings it uses are supplied by coating manufacturers that use
the procedures in "Procedures for Certifying Quantity of Volatile Organic
Compounds Emitted by Paints, Ink, and Other Coatings" (revised June 1986), U.S.
EPA 450/ 3-84-019 ** to certify the VOC content of coatings and
thinners.
(C) The source may use
the alternative procedure during the time the application is being reviewed by
the department and the U.S. EPA.
(5) The department may test or have tested
any coating for VOC content using 40 CFR 60, Appendix A, Method 24*. If there
is a discrepancy between the results of testing for VOC content, Method 24 test
results shall take precedence.
*These documents are incorporated by reference. Copies may be
obtained from the Government Printing Office, 732 North Capitol Street NW,
Washington, D.C. 20401 or are available for review and copying at the Indiana
Department of Environmental Management, Office of Air Quality, Indiana
Government Center-North, Tenth Floor, 100 North Senate Avenue, Indianapolis,
Indiana 46204.
**These documents are incorporated by reference. Copies are
available for review and copying at the Indiana Department of Environmental
Management, Office of Air Quality, Indiana Government Center-North, Tenth
Floor, 100 North Senate Avenue, Indianapolis, Indiana 46204.
