Airworthiness Directives; Cessna Aircraft Company Airplanes, 60062-60064 [2012-24207]

Download as PDF 60062 Federal Register / Vol. 77, No. 191 / Tuesday, October 2, 2012 / Proposed Rules email thd.qseries@aero.bombardier.com; Internet https://www.bombardier.com. You may review copies of the referenced service information at the FAA, Transport Airplane Directorate, 1601 Lind Avenue SW., Renton, WA. For information on the availability of this material at the FAA, call 425–227–1221. Issued in Renton, Washington, on September 21, 2012. Ali Bahrami, Manager, Transport Airplane Directorate, Aircraft Certification Service. [FR Doc. 2012–24174 Filed 10–1–12; 8:45 am] BILLING CODE 4910–13–P DEPARTMENT OF TRANSPORTATION Federal Aviation Administration 14 CFR Part 39 [Docket No. FAA–2012–1052; Directorate Identifier 2012–CE–014–AD] Examining the AD Docket RIN 2120–AA64 Airworthiness Directives; Cessna Aircraft Company Airplanes Federal Aviation Administration (FAA), DOT. ACTION: Notice of proposed rulemaking (NPRM). AGENCY: We propose to supersede an existing airworthiness directive (AD) that applies to certain Cessna Aircraft Company (Cessna) Models 172R, 172S, 182S, 182T, T182T, 206H, and T206H airplanes. The existing AD currently requires an inspection of the engine oil pressure switch and, if applicable, replacement of the engine oil pressure switch. Since we issued that AD, we have received new reports of internal failure of the engine oil pressure switch, which could result in complete loss of engine oil with consequent partial or complete loss of engine power or fire. This proposed AD would increase the applicability of the AD and place a lifelimit of 3,000 hours time-in-service on the engine oil pressure switch, requiring replacement when the engine oil pressure switch reaches its life limit. We are proposing this AD to correct the unsafe condition on these products. DATES: We must receive comments on this proposed AD by November 16, 2012. ADDRESSES: You may send comments, using the procedures found in 14 CFR 11.43 and 11.45, by any of the following methods: • Federal eRulemaking Portal: Go to https://www.regulations.gov. Follow the instructions for submitting comments. • Fax: 202–493–2251. • Mail: U.S. Department of Transportation, Docket Operations, M– wreier-aviles on DSK5TPTVN1PROD with PROPOSALS SUMMARY: VerDate Mar<15>2010 14:57 Oct 01, 2012 Jkt 229001 30, West Building Ground Floor, Room W12–140, 1200 New Jersey Avenue SE., Washington, DC 20590. • Hand Delivery: Deliver to Mail address above between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. For service information identified in this proposed AD, contact Cessna Aircraft Company, Product Support, P.O. Box 7706, Wichita, Kansas 67277; telephone: (316) 517–5800; fax (316) 942–9006; Internet: www.cessna.com/ customer-service/technicalpublications.html. You may review copies of the referenced service information at the FAA, Small Airplane Directorate, 901 Locust, Kansas City, Missouri 64106. For information on the availability of this material at the FAA, call (816) 329–4148. You may examine the AD docket on the Internet at https://www.regulations. gov; or in person at the Docket Management Facility between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this proposed AD, the regulatory evaluation, any comments received, and other information. The street address for the Docket Office (phone: 800–647–5527) is in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt. FOR FURTHER INFORMATION CONTACT: Jeff Janusz, Sr. Propulsion Engineer, Wichita Aircraft Certification Office, FAA, 1801 Airport Road, Wichita, KS 67209; phone: (316) 946–4148; fax: (316) 946– 4107; email: jeff.janusz@faa.gov. SUPPLEMENTARY INFORMATION: Comments Invited We invite you to send any written relevant data, views, or arguments about this proposed AD. Send your comments to an address listed under the ADDRESSES section. Include ‘‘Docket No. FAA–2012–1052; Directorate Identifier 2012–CE–014–AD’’ at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of this proposed AD. We will consider all comments received by the closing date and may amend this proposed AD because of those comments. We will post all comments we receive, without change, to https://www. regulations.gov, including any personal information you provide. We will also post a report summarizing each substantive verbal contact we receive about this proposed AD. PO 00000 Frm 00006 Fmt 4702 Sfmt 4702 Discussion On February 11, 2000, we issued AD 2000–04–01, amendment 39–11583 (65 FR 8649, February 22, 2000), for certain Cessna Aircraft Company Models 172R, 172S, 182S, 206H, and T206H airplanes. That AD requires inspection of the engine oil pressure switch to determine if the engine oil pressure switch is partnumber (P/N) 77041 or P/N 83278 and replacement of any P/N 77041 engine oil pressure switch with a P/N 83278 engine oil pressure switch. That AD resulted from reports of failure of the engine oil pressure switch diaphragm. We issued that AD to prevent loss of engine oil through the failure of the engine oil pressure switch diaphragm, which could result in partial or complete loss of engine power. Actions Since Existing AD Was Issued Since we issued AD 2000–04–01, amendment 39–11583 (65 FR 8649, February 22, 2000), we have received new reports of internal failure of the engine oil pressure switch, which could result in complete loss of engine oil with consequent partial or complete loss of engine power or fire. Relevant Service Information We reviewed Cessna Service Bulletin 07–79–01, dated January 29, 2007. The service information describes procedures for replacement of the engine oil pressure switch. FAA’s Determination We are proposing this AD because we evaluated all the relevant information and determined the unsafe condition described previously is likely to exist or develop in other products of these same type designs. Proposed AD Requirements This proposed AD would retain none of the requirements of AD 2000–04–01, amendment 39–11583 (65 FR 8649, February 22, 2000). This proposed AD would increase the applicability statement of the existing AD and require an inspection of the engine oil pressure switch with replacement of the engine oil pressure switch when it reaches its life limit of 3,000 hours time-in-service. We are proposing this AD to correct the unsafe condition on these products. Differences Between the Proposed AD and the Service Information Applicability in this proposed AD has been expanded to include additional airplane serial numbers. Costs of Compliance We estimate that this proposed AD affects 6,155 airplanes of U.S. registry. E:\FR\FM\02OCP1.SGM 02OCP1 Federal Register / Vol. 77, No. 191 / Tuesday, October 2, 2012 / Proposed Rules 60063 We estimate the following costs to comply with this proposed AD: ESTIMATED COSTS Cost per product Cost on U.S. operators Action Labor cost Parts cost Inspection of the airplane or engine records. Inspection of the engine oil pressure switch installation. Removal and replacement of the engine oil pressure switch and logbook entry. .5 work-hour × $85 per hour = $42.50 .. Not applicable .............. $42.50 $261,587.50 .5 work-hour × $85 per hour = $42.50 .. Not applicable .............. 42.50 261,587.50 .5 work-hour × $85 per hour = $42.50 .. $54 ............................... 96.50 593,957.50 Authority for This Rulemaking Title 49 of the United States Code specifies the FAA’s authority to issue rules on aviation safety. Subtitle I, Section 106, describes the authority of the FAA Administrator. Subtitle VII, Aviation Programs, describes in more detail the scope of the Agency’s authority. We are issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, Section 44701, ‘‘General requirements.’’ Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action. wreier-aviles on DSK5TPTVN1PROD with PROPOSALS Regulatory Findings We have determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government. For the reasons discussed above, I certify that the proposed regulation: (1) Is not a ‘‘significant regulatory action’’ under Executive Order 12866, (2) Is not a ‘‘significant rule’’ under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979), (3) Will not affect intrastate aviation in Alaska, and (4) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act. VerDate Mar<15>2010 14:57 Oct 01, 2012 Jkt 229001 List of Subjects in 14 CFR Part 39 Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety. The Proposed Amendment Accordingly, under the authority delegated to me by the Administrator, the FAA proposes to amend 14 CFR part 39 as follows: PART 39—AIRWORTHINESS DIRECTIVES 1. The authority citation for part 39 continues to read as follows: Authority: 49 U.S.C. 106(g), 40113, 44701. § 39.13 [Amended] 2. The FAA amends § 39.13 by removing airworthiness directive (AD) 2000–04–01, Amendment 39–11583 (65 FR 8649, February 22, 2000), and adding the following new AD: Cessna Aircraft Company: Docket No. FAA– 2012–1052; Directorate Identifier 2012– CE–014–AD. (a) Comments Due Date The FAA must receive comments on this AD action by November 16, 2012. (b) Affected ADs This AD supersedes AD 2000–04–01, Amendment 39–11583 (65 FR 8649, February 22, 2000). (c) Applicability This AD applies to Cessna Aircraft Company Models 172R, serial numbers (S/N) 17280001 through 17281622; 172S, S/N 172S8001 through 172S11244; 182S, S/N 18280001 through 18280944; 182T, S/N 18280945 through 18282356; T182T, S/N T18208001 through T18209096; 206H, S/N 20608001 through 20608350; and T206H, S/ N T20608001 through T20609079; certificated in any category. (d) Subject Joint Aircraft System Component (JASC)/ Air Transport Association (ATA) of America Code 7931, Engine Oil Pressure. (e) Unsafe Condition This AD was prompted by new reports of internal failure of the engine oil pressure PO 00000 Frm 00007 Fmt 4702 Sfmt 4702 switch, which could result in complete loss of engine oil with consequent partial or complete loss of engine power or fire. We are issuing this AD to place a life-limit on the engine oil pressure switch after which replacement would be required. (f) Compliance Comply with this AD within the compliance times specified, following Cessna Service Bulletin SB 07–79–01, dated January 29, 2007, unless already done. (g) Actions (1) At the next scheduled oil change, annual inspection, or 100-hour inspection after the effective date of this AD, whichever occurs later, but in no case later than 12 months after the effective date of this AD, inspect the engine oil pressure switch to determine if it is part-number (P/N) 77041 or P/N 83278. (2) If after the inspection required in paragraph (g)(1) of this AD, P/N 77041 engine oil pressure switch is installed, before further flight, replace the engine oil pressure switch with a new, zero time, P/N 83278 engine oil pressure switch. Record the engine oil pressure switch part number, date, and airplane hours TIS in the airplane log book. The recorded engine oil pressure switch TIS will be used as the benchmark for calculation of the 3,000 hour TIS limit on the engine oil pressure switch. (3) After the effective date of this AD, do not install a P/N 77041 engine oil pressure switch on any affected airplane. (4) If after the inspection required in paragraph (g)(1) of this AD it is confirmed that P/N 83278 engine oil pressure switch is installed, through inspection of the airplane or engine logbooks determine the TIS of the engine oil pressure switch. (5) If after the inspection required in paragraph (g)(1) of this AD you cannot positively identify the hours TIS on the P/N 83278 engine oil pressure switch, before further flight, replace the engine oil pressure switch with a new, zero time, P/N 83278 engine oil pressure switch. Record the engine oil pressure switch part number, date, and airplane hours in the airplane log book. The recorded engine oil pressure switch TIS will be used as the benchmark for calculation of the 3,000 hour TIS limit on the engine oil pressure switch. (6) When the engine oil pressure switch is at or greater than 3,000 hours TIS or within 50 hours TIS after the effective date of this AD, whichever occurs later, and repetitively E:\FR\FM\02OCP1.SGM 02OCP1 60064 Federal Register / Vol. 77, No. 191 / Tuesday, October 2, 2012 / Proposed Rules thereafter at intervals not to exceed 3,000 hours TIS on the P/N 83278 engine oil pressure switch, replace it with a new, zero time, P/N 83278 engine oil pressure switch. Record the engine oil pressure switch part number, date, and airplane hours in the airplane log book. The recorded engine oil pressure switch TIS will be used as the benchmark for calculation of the 3,000 hour TIS limit on the engine oil pressure switch. (h) Alternative Methods of Compliance (AMOCs) (1) The Manager, Wichita Aircraft Certification Office (ACO), FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14 CFR 39.19, send your request to your principal inspector or local Flight Standards District Office, as appropriate. If sending information directly to the manager of the ACO, send it to the attention of the person identified in the Related Information section of this AD. (2) Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, the manager of the local flight standards district office/ certificate holding district office. (i) Related Information (1) For more information about this AD, contact Jeff Janusz, Sr. Propulsion Engineer, Wichita ACO, FAA, 1801 Airport Road, Wichita, KS 67209 phone: (316) 946–4148; fax: (316) 946–4107; email: jeff.janusz@faa. gov. (2) For service information identified in this AD, contact Cessna Aircraft Company, Product Support, P.O. Box 7706, Wichita, Kansas 67277; telephone: (316) 517–5800; fax (316) 942–9006; Internet: www.cessna.com/ customer-service/technical-publications. html. You may review copies of the referenced service information at the FAA, Small Airplane Directorate, 901 Locust, Kansas City, Missouri 64106. For information on the availability of this material at the FAA, call (816) 329–4148. Issued in Kansas City, Missouri, on September 26, 2012. Earl Lawrence, Manager, Small Airplane Directorate, Aircraft Certification Service. [FR Doc. 2012–24207 Filed 10–1–12; 8:45 am] BILLING CODE 4910–13–P DEPARTMENT OF TRANSPORTATION Federal Aviation Administration wreier-aviles on DSK5TPTVN1PROD with PROPOSALS 14 CFR Part 39 [Docket No. FAA–2012–1034; Directorate Identifier 2011–NM–051–AD] RIN 2120–AA64 Airworthiness Directives; Airbus Airplanes Federal Aviation Administration (FAA), DOT. AGENCY: VerDate Mar<15>2010 14:57 Oct 01, 2012 Jkt 229001 Notice of proposed rulemaking (NPRM). ACTION: We propose to supersede an existing airworthiness directive (AD) that applies to certain Airbus Model A318, A319, A320, and A321 series airplanes. The existing AD currently requires one-time and repetitive inspections of specific areas and, when necessary, corrective actions for those rudders where production rework has been identified. Since we issued that AD, we have determined that additional inspections and corrective actions are necessary to address the identified unsafe condition, and that additional airplanes with certain rudders are subject to the identified unsafe condition. This proposed AD would add airplanes with certain rudders to the AD applicability; change an inspection type for certain reinforced rudder areas; require pre-inspections and repairs if needed; and require permanent restoration of vacuum loss holes. This proposed AD would also require additional inspections for certain rudders and repair if needed; and require replacement of certain rudders with new rudders. We are proposing this AD to detect and correct extended de-bonding, which might degrade the structural integrity of the rudder. The loss of the rudder leads to degradation of the handling qualities and reduces the controllability of the airplane. DATES: We must receive comments on this proposed AD by November 16, 2012. SUMMARY: You may send comments by any of the following methods: • Federal eRulemaking Portal: Go to https://www.regulations.gov. Follow the instructions for submitting comments. • Fax: (202) 493–2251. • Mail: U.S. Department of Transportation, Docket Operations, M– 30, West Building Ground Floor, Room W12–140, 1200 New Jersey Avenue SE., Washington, DC 20590. • Hand Delivery: U.S. Department of Transportation, Docket Operations, M– 30, West Building Ground Floor, Room W12–40, 1200 New Jersey Avenue SE., Washington, DC, between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. For service information identified in this proposed AD, contact Airbus, Airworthiness Office—EAS, 1 Rond Point Maurice Bellonte, 31707 Blagnac Cedex, France; telephone +33 5 61 93 36 96; fax +33 5 61 93 44 51; email account.airworth-eas@airbus.com; Internet https://www.airbus.com. You may review copies of the referenced service information at the FAA, ADDRESSES: PO 00000 Frm 00008 Fmt 4702 Sfmt 4702 Transport Airplane Directorate, 1601 Lind Avenue SW., Renton, WA. For information on the availability of this material at the FAA, call 425–227–1221. Examining the AD Docket You may examine the AD docket on the Internet at https:// www.regulations.gov; or in person at the Docket Operations office between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this proposed AD, the regulatory evaluation, any comments received, and other information. The street address for the Docket Operations office (telephone (800) 647–5527) is in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt. FOR FURTHER INFORMATION CONTACT: Sanjay Ralhan, Aerospace Engineer, International Branch, ANM–116, Transport Airplane Directorate, FAA, 1601 Lind Avenue SW., Renton, WA 98057–3356; telephone (425) 227–1405; fax (425) 227–1149. SUPPLEMENTARY INFORMATION: Comments Invited We invite you to send any written relevant data, views, or arguments about this proposed AD. Send your comments to an address listed under the ADDRESSES section. Include ‘‘Docket No. FAA–2012–1034; Directorate Identifier 2011–NM–051–AD’’ at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of this proposed AD. We will consider all comments received by the closing date and may amend this proposed AD based on those comments. We will post all comments we receive, without change, to https:// www.regulations.gov, including any personal information you provide. We will also post a report summarizing each substantive verbal contact we receive about this proposed AD. Discussion On October 26, 2010, we issued AD 2010–23–07, Amendment 39–16496 (75 FR 68181, November 5, 2010; corrected December 17, 2010 (75 FR 78883)). That AD required actions intended to address an unsafe condition on the products listed above. The European Aviation Safety Agency (EASA), which is the Technical Agent for the Member States of the European Community, has issued EASA Airworthiness Directive 2010–0164, dated August 5, 2010 (referred to after this as ‘‘the MCAI’’), to correct an unsafe condition for the specified products. The MCAI states: E:\FR\FM\02OCP1.SGM 02OCP1

Agencies

[Federal Register Volume 77, Number 191 (Tuesday, October 2, 2012)]
[Proposed Rules]
[Pages 60062-60064]
From the Federal Register Online via the Government Printing Office [www.gpo.gov]
[FR Doc No: 2012-24207]


-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. FAA-2012-1052; Directorate Identifier 2012-CE-014-AD]
RIN 2120-AA64


Airworthiness Directives; Cessna Aircraft Company Airplanes

AGENCY: Federal Aviation Administration (FAA), DOT.

ACTION: Notice of proposed rulemaking (NPRM).

-----------------------------------------------------------------------

SUMMARY: We propose to supersede an existing airworthiness directive 
(AD) that applies to certain Cessna Aircraft Company (Cessna) Models 
172R, 172S, 182S, 182T, T182T, 206H, and T206H airplanes. The existing 
AD currently requires an inspection of the engine oil pressure switch 
and, if applicable, replacement of the engine oil pressure switch. 
Since we issued that AD, we have received new reports of internal 
failure of the engine oil pressure switch, which could result in 
complete loss of engine oil with consequent partial or complete loss of 
engine power or fire. This proposed AD would increase the applicability 
of the AD and place a life-limit of 3,000 hours time-in-service on the 
engine oil pressure switch, requiring replacement when the engine oil 
pressure switch reaches its life limit. We are proposing this AD to 
correct the unsafe condition on these products.

DATES: We must receive comments on this proposed AD by November 16, 
2012.

ADDRESSES: You may send comments, using the procedures found in 14 CFR 
11.43 and 11.45, by any of the following methods:
     Federal eRulemaking Portal: Go to https://www.regulations.gov. Follow the instructions for submitting comments.
     Fax: 202-493-2251.
     Mail: U.S. Department of Transportation, Docket 
Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New 
Jersey Avenue SE., Washington, DC 20590.
     Hand Delivery: Deliver to Mail address above between 9 
a.m. and 5 p.m., Monday through Friday, except Federal holidays.
    For service information identified in this proposed AD, contact 
Cessna Aircraft Company, Product Support, P.O. Box 7706, Wichita, 
Kansas 67277; telephone: (316) 517-5800; fax (316) 942-9006; Internet: 
www.cessna.com/customer-service/technical-publications.html. You may 
review copies of the referenced service information at the FAA, Small 
Airplane Directorate, 901 Locust, Kansas City, Missouri 64106. For 
information on the availability of this material at the FAA, call (816) 
329-4148.

Examining the AD Docket

    You may examine the AD docket on the Internet at https://www.regulations.gov; or in person at the Docket Management Facility 
between 9 a.m. and 5 p.m., Monday through Friday, except Federal 
holidays. The AD docket contains this proposed AD, the regulatory 
evaluation, any comments received, and other information. The street 
address for the Docket Office (phone: 800-647-5527) is in the ADDRESSES 
section. Comments will be available in the AD docket shortly after 
receipt.

FOR FURTHER INFORMATION CONTACT: Jeff Janusz, Sr. Propulsion Engineer, 
Wichita Aircraft Certification Office, FAA, 1801 Airport Road, Wichita, 
KS 67209; phone: (316) 946-4148; fax: (316) 946-4107; email: 
jeff.janusz@faa.gov.

SUPPLEMENTARY INFORMATION:

Comments Invited

    We invite you to send any written relevant data, views, or 
arguments about this proposed AD. Send your comments to an address 
listed under the ADDRESSES section. Include ``Docket No. FAA-2012-1052; 
Directorate Identifier 2012-CE-014-AD'' at the beginning of your 
comments. We specifically invite comments on the overall regulatory, 
economic, environmental, and energy aspects of this proposed AD. We 
will consider all comments received by the closing date and may amend 
this proposed AD because of those comments.
    We will post all comments we receive, without change, to https://www.regulations.gov, including any personal information you provide. We 
will also post a report summarizing each substantive verbal contact we 
receive about this proposed AD.

Discussion

    On February 11, 2000, we issued AD 2000-04-01, amendment 39-11583 
(65 FR 8649, February 22, 2000), for certain Cessna Aircraft Company 
Models 172R, 172S, 182S, 206H, and T206H airplanes. That AD requires 
inspection of the engine oil pressure switch to determine if the engine 
oil pressure switch is part-number (P/N) 77041 or P/N 83278 and 
replacement of any P/N 77041 engine oil pressure switch with a P/N 
83278 engine oil pressure switch. That AD resulted from reports of 
failure of the engine oil pressure switch diaphragm. We issued that AD 
to prevent loss of engine oil through the failure of the engine oil 
pressure switch diaphragm, which could result in partial or complete 
loss of engine power.

Actions Since Existing AD Was Issued

    Since we issued AD 2000-04-01, amendment 39-11583 (65 FR 8649, 
February 22, 2000), we have received new reports of internal failure of 
the engine oil pressure switch, which could result in complete loss of 
engine oil with consequent partial or complete loss of engine power or 
fire.

Relevant Service Information

    We reviewed Cessna Service Bulletin 07-79-01, dated January 29, 
2007. The service information describes procedures for replacement of 
the engine oil pressure switch.

FAA's Determination

    We are proposing this AD because we evaluated all the relevant 
information and determined the unsafe condition described previously is 
likely to exist or develop in other products of these same type 
designs.

Proposed AD Requirements

    This proposed AD would retain none of the requirements of AD 2000-
04-01, amendment 39-11583 (65 FR 8649, February 22, 2000). This 
proposed AD would increase the applicability statement of the existing 
AD and require an inspection of the engine oil pressure switch with 
replacement of the engine oil pressure switch when it reaches its life 
limit of 3,000 hours time-in-service. We are proposing this AD to 
correct the unsafe condition on these products.

Differences Between the Proposed AD and the Service Information

    Applicability in this proposed AD has been expanded to include 
additional airplane serial numbers.

Costs of Compliance

    We estimate that this proposed AD affects 6,155 airplanes of U.S. 
registry.

[[Page 60063]]

    We estimate the following costs to comply with this proposed AD:

                                                 Estimated Costs
----------------------------------------------------------------------------------------------------------------
                                                                                     Cost per      Cost on U.S.
              Action                      Labor cost              Parts cost          product        operators
----------------------------------------------------------------------------------------------------------------
Inspection of the airplane or      .5 work-hour x $85 per    Not applicable.....          $42.50     $261,587.50
 engine records.                    hour = $42.50.
Inspection of the engine oil       .5 work-hour x $85 per    Not applicable.....           42.50      261,587.50
 pressure switch installation.      hour = $42.50.
Removal and replacement of the     .5 work-hour x $85 per    $54................           96.50      593,957.50
 engine oil pressure switch and     hour = $42.50.
 logbook entry.
----------------------------------------------------------------------------------------------------------------

Authority for This Rulemaking

    Title 49 of the United States Code specifies the FAA's authority to 
issue rules on aviation safety. Subtitle I, Section 106, describes the 
authority of the FAA Administrator. Subtitle VII, Aviation Programs, 
describes in more detail the scope of the Agency's authority.
    We are issuing this rulemaking under the authority described in 
Subtitle VII, Part A, Subpart III, Section 44701, ``General 
requirements.'' Under that section, Congress charges the FAA with 
promoting safe flight of civil aircraft in air commerce by prescribing 
regulations for practices, methods, and procedures the Administrator 
finds necessary for safety in air commerce. This regulation is within 
the scope of that authority because it addresses an unsafe condition 
that is likely to exist or develop on products identified in this 
rulemaking action.

Regulatory Findings

    We have determined that this proposed AD would not have federalism 
implications under Executive Order 13132. This proposed AD would not 
have a substantial direct effect on the States, on the relationship 
between the national Government and the States, or on the distribution 
of power and responsibilities among the various levels of government.
    For the reasons discussed above, I certify that the proposed 
regulation:
    (1) Is not a ``significant regulatory action'' under Executive 
Order 12866,
    (2) Is not a ``significant rule'' under the DOT Regulatory Policies 
and Procedures (44 FR 11034, February 26, 1979),
    (3) Will not affect intrastate aviation in Alaska, and
    (4) Will not have a significant economic impact, positive or 
negative, on a substantial number of small entities under the criteria 
of the Regulatory Flexibility Act.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

The Proposed Amendment

    Accordingly, under the authority delegated to me by the 
Administrator, the FAA proposes to amend 14 CFR part 39 as follows:

PART 39--AIRWORTHINESS DIRECTIVES

    1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec.  39.13  [Amended]

    2. The FAA amends Sec.  39.13 by removing airworthiness directive 
(AD) 2000-04-01, Amendment 39-11583 (65 FR 8649, February 22, 2000), 
and adding the following new AD:

Cessna Aircraft Company: Docket No. FAA-2012-1052; Directorate 
Identifier 2012-CE-014-AD.

(a) Comments Due Date

    The FAA must receive comments on this AD action by November 16, 
2012.

(b) Affected ADs

    This AD supersedes AD 2000-04-01, Amendment 39-11583 (65 FR 
8649, February 22, 2000).

(c) Applicability

    This AD applies to Cessna Aircraft Company Models 172R, serial 
numbers (S/N) 17280001 through 17281622; 172S, S/N 172S8001 through 
172S11244; 182S, S/N 18280001 through 18280944; 182T, S/N 18280945 
through 18282356; T182T, S/N T18208001 through T18209096; 206H, S/N 
20608001 through 20608350; and T206H, S/N T20608001 through 
T20609079; certificated in any category.

(d) Subject

    Joint Aircraft System Component (JASC)/Air Transport Association 
(ATA) of America Code 7931, Engine Oil Pressure.

(e) Unsafe Condition

    This AD was prompted by new reports of internal failure of the 
engine oil pressure switch, which could result in complete loss of 
engine oil with consequent partial or complete loss of engine power 
or fire. We are issuing this AD to place a life-limit on the engine 
oil pressure switch after which replacement would be required.

(f) Compliance

    Comply with this AD within the compliance times specified, 
following Cessna Service Bulletin SB 07-79-01, dated January 29, 
2007, unless already done.

(g) Actions

    (1) At the next scheduled oil change, annual inspection, or 100-
hour inspection after the effective date of this AD, whichever 
occurs later, but in no case later than 12 months after the 
effective date of this AD, inspect the engine oil pressure switch to 
determine if it is part-number (P/N) 77041 or P/N 83278.
    (2) If after the inspection required in paragraph (g)(1) of this 
AD, P/N 77041 engine oil pressure switch is installed, before 
further flight, replace the engine oil pressure switch with a new, 
zero time, P/N 83278 engine oil pressure switch. Record the engine 
oil pressure switch part number, date, and airplane hours TIS in the 
airplane log book. The recorded engine oil pressure switch TIS will 
be used as the benchmark for calculation of the 3,000 hour TIS limit 
on the engine oil pressure switch.
    (3) After the effective date of this AD, do not install a P/N 
77041 engine oil pressure switch on any affected airplane.
    (4) If after the inspection required in paragraph (g)(1) of this 
AD it is confirmed that P/N 83278 engine oil pressure switch is 
installed, through inspection of the airplane or engine logbooks 
determine the TIS of the engine oil pressure switch.
    (5) If after the inspection required in paragraph (g)(1) of this 
AD you cannot positively identify the hours TIS on the P/N 83278 
engine oil pressure switch, before further flight, replace the 
engine oil pressure switch with a new, zero time, P/N 83278 engine 
oil pressure switch. Record the engine oil pressure switch part 
number, date, and airplane hours in the airplane log book. The 
recorded engine oil pressure switch TIS will be used as the 
benchmark for calculation of the 3,000 hour TIS limit on the engine 
oil pressure switch.
    (6) When the engine oil pressure switch is at or greater than 
3,000 hours TIS or within 50 hours TIS after the effective date of 
this AD, whichever occurs later, and repetitively

[[Page 60064]]

thereafter at intervals not to exceed 3,000 hours TIS on the P/N 
83278 engine oil pressure switch, replace it with a new, zero time, 
P/N 83278 engine oil pressure switch. Record the engine oil pressure 
switch part number, date, and airplane hours in the airplane log 
book. The recorded engine oil pressure switch TIS will be used as 
the benchmark for calculation of the 3,000 hour TIS limit on the 
engine oil pressure switch.

(h) Alternative Methods of Compliance (AMOCs)

    (1) The Manager, Wichita Aircraft Certification Office (ACO), 
FAA, has the authority to approve AMOCs for this AD, if requested 
using the procedures found in 14 CFR 39.19. In accordance with 14 
CFR 39.19, send your request to your principal inspector or local 
Flight Standards District Office, as appropriate. If sending 
information directly to the manager of the ACO, send it to the 
attention of the person identified in the Related Information 
section of this AD.
    (2) Before using any approved AMOC, notify your appropriate 
principal inspector, or lacking a principal inspector, the manager 
of the local flight standards district office/certificate holding 
district office.

(i) Related Information

    (1) For more information about this AD, contact Jeff Janusz, Sr. 
Propulsion Engineer, Wichita ACO, FAA, 1801 Airport Road, Wichita, 
KS 67209 phone: (316) 946-4148; fax: (316) 946-4107; email: 
jeff.janusz@faa.gov.
    (2) For service information identified in this AD, contact 
Cessna Aircraft Company, Product Support, P.O. Box 7706, Wichita, 
Kansas 67277; telephone: (316) 517-5800; fax (316) 942-9006; 
Internet: www.cessna.com/customer-service/technical-publications.html. You may review copies of the referenced service 
information at the FAA, Small Airplane Directorate, 901 Locust, 
Kansas City, Missouri 64106. For information on the availability of 
this material at the FAA, call (816) 329-4148.

    Issued in Kansas City, Missouri, on September 26, 2012.
Earl Lawrence,
Manager, Small Airplane Directorate, Aircraft Certification Service.
[FR Doc. 2012-24207 Filed 10-1-12; 8:45 am]
BILLING CODE 4910-13-P
This site is protected by reCAPTCHA and the Google Privacy Policy and Terms of Service apply.